Sunday, July 5, 2015

Loading Blackhorn 209 in Bottleneck Cases



       Norm shooting 308 with Blackhorn 209  

                                          Blackhorn 209 In Bottleneck Cases
 In the past, I have used this propellant in applications that it wasn’t designed for. It is a type of black powder substitute for some but not all black powder weapons. Since it is hard to ignite cap & ball guns and 209 don’t mix. Also small cartridges especially with light bullets perform poorly with 209. Most blanks do better with other propellants. With the insanity going on many smokeless powders are difficult to get. I have walked into a few gun stores and saw bare shelves where the powder usually resided.  With that thought in mind, 209 can be looked at as an all around powder. While it isn’t perfect it will work in a broader range of guns then anything else I have tried. In a pinch perfection isn’t what we are looking for but a chance for survival. With the broad spectrum of calibers I have worked with this is the closest to the perfect all around propellant. Real small rounds such as the 25 and 32 ACP sizes it won’t do very well and may not work at all.

 I have used it with success on such diverse rounds as a 12 gauge and 45 auto. We have shot quail with this powder and it functioned a Benelli semi auto. Shooting a 1 oz. slug 209 works fine producing about 1,000 FPS which would be perfect for home defense. Therefore, to explore other possibilities the idea of modern bottleneck rifle rounds occurred to me. Why not try it in such offerings as a 22-250, 243 and 30-06. The 30-30 and other similar common rounds would be a good testing ground.     The idea is to develop a load powerful enough to be useful at closer ranges that you might need in a pinch. Of course, velocity will be less then a standard load but if it is accurate enough at 25 to 50 yards with decent velocity then we can consider it useful. Some of these loads should work well at a hundred yards and perhaps a bit beyond.   At the time of this writing powder is extremely difficult to get anywhere and some private sellers are selling it online for two or three times the going price. Unfortunately there are sleaze bags taking advantage of the situation.  For your information, I checked with a couple of distributors to see what powders of any kind are available. With smokeless powders, over 95% are not available while black powder and substitutes including 209 are almost 100 % available. In honesty the 209 is more expensive then the other brands since it is tubular and hollow it is more difficult to make.  That should give those who reload something to think about though for an emergency cost isn’t a factor.  You do use less 209 because it  such a low density which will help with cost for the economically minded folks.  In a real pinch you can use black powder and Pyrodex in rifles but keep in mind that they are corrosive and you velocity will drop even more. I have done this and for emergency purposes, it will do. In small bore guns the barrel will be fouled up after a few shots something to keep in mind. Use compressed loads in all of the rounds used.

7 mm   Remington mag produces smoke with 209 

 It is a very low-density powder so compressed loads will be the order of the day. In fact, the jug that I received is the standard size for 8 LBS but only 5 will fit in there. I hope that the powder situation will improve but one should be prepared and learning to use alternate powders is one way to improve the ammo situation. Most of the stand byes will not work as well but will do in a pinch. For instance you can use small amounts of pistol powder in a rifle. You will lose much of your velocity but at closer ranges it may do ok. You just have to be careful not to use too much as that may cause dangerous pressure spikes. For example, you can use a small amount of Unique in a 30-06. You will get some useful velocity and accuracy. In fact, with cast bullets it is an excellent choice. Blackhorn 209 is meant as a high performance propellant for certain muzzle loading arms mainly inlines. It is somewhat difficult to ignite so conventional cap locks and flintlocks won’t work well with it. Surprisingly it meters pretty well in my powder measure considering the size of the grains. Real small capacity rounds don’t do very well with it as velocity is low but for larger cases it works well. I have been successful on making in work and function in a 45 ACP and a 12 ga semi auto. My loads in the shotgun have been good enough to harvest quail. I see some promising possibilities in using it for modern bottle neck cases. Like all black powder and their substitutes, it is recommended not to have airspace between the bullet and powder so all of my loads will be compressed. In addition, the idea is to see how much velocity we can safely get out of this propellant. Accuracy is also a consideration along with function in a semi auto.  The 30-06 produces enough velocity with a hunting bullet to make it useful. It is in the same area as a 30-30 load which will enable game to be harvested at 100 yards or so. Of course 30-30 bullets can be used to produce the same results as the 30-30.    


300 Win mag ammo

 The 223 is so popular that 209 should be tried in it. With the small case, I don’t expect a lot but am going to try some heavy 75 to 80 grain bullets. With the 55 grain bullets they ejected but the bolt didn’t always come back far enough to pick up another round. The heavier bullets worked perfectly. The rifle used was a mag change model which is capable of utilizing four different calibers. Barrel was 16” and the velocity while lower then standard 223 would none the less be useful for some work. With the 77 grain bullet a fast twist would be required to stabilize it. With the mild velocities encountered, most cup and core bullets should work ok for most situations. That is one of the advantages of these loads is standard cup and core bullets will produce good results. They will not come unglued as possible with high velocity loads. Thin-jacketed varmint bullets should be excellent defense ammo. Your ES and SD are a result of the compatibility of the powder and bullet. I am working on a piece explaining that in detail. 
LOAD                                         BULLET                                   VELOCITY                                   COMMENT
21 grains                                  55 grain FMJ                          2110                                              es 110
20 grains                                  77 grain Horn HP                 1863                                            more consistent  
 





 The 22-250 is fairly common and since it has more capacity then a 223 the heavy bullets might work fairly well. Like all of the rounds, being tested results will be similar in similar cases such as the 220 Swift. The 100 grain is an unusually heavy bullet for a 22 and you would need a barrel with a fast twist to stabilize it.   The velocities displayed by the 22-250 would be useful for deer given good bullet placement and a twist fast enough to stabilize a 100 grain bullet.  The 100 grain has a high sectional density hence it should have a lot of penetration.
LOAD                                         BULLET                                 VELOCITY                                    COMMENT
30 grains                                  55 grain FMJ                        2829                                            ok
27 grains                                 100 grain                              2204                                            nice 
 Another round that is common is the 243. I am trying a heavily compressed load with a 100 grain flat base bullet. Like all of the other rifles tested though some velocity is lost it will still harvest a deer sized animal at moderate ranges. A 100 grain bullet in the 243 has decent sectional density which would enable it to provide adequate penetration. Since the velocity is fairly low bullet shape and jacket thickness are not as important as it is in higher velocity loads. Round nose bullets would work great since they have a propensity to expand at lower velocities and give adequate penetration. This will be true in any of the calibers tested.   
LOAD                                       BULLET                                    VELOCITY                                         COMMENT
38 grains                                100 grain Trophy Bond         2440                                                 consistent

 The 270 Winchester has been around for many years and is common and well known so it would be appropriate to list a couple of loads for it. For some reason the 130 grain load wasn’t consistent which goes against most of the other loads tested in the 270 and the other rifles. Typically most of the loads were consistent.  The nice thing is since the pressure is low top grade cases are not necessary. I used brass that was fired several times and it performed well. I just did the routine checks which included checking for splits and case length.  
LOAD                                             BULLET                                        VELOCITY                                       COMMENT
45 grains                                130 grain Speer Grand Slam          2249                                              high ES
42 grains                                150 grain Hornady SST  BT            2265                         




                   

308 with 209

 The 7 mm -08 started out as a wildcat but was later adopted. It is a 308 necked down with no other changes. It is a good hunting round giving good ballistics with very moderate recoil. Bullets from 100 to 175 grains are usable and anyone who makes ammo does the 08. There is a good selection of lightweight rifles available many at inexpensive prices. This is just another example of a rifle that can be useful with 209. Those velocities are enough to harvest a deer at closer ranges or it is very adequate for home defense. If you use a cartridge similar to the listed ones results will be similar. A 260 Remington would give results similar to the 7 mm 08 given similar bullet weight and sectional density and barrel length
LOAD                                     BULLET                                             VELOCITY                                COMMENT
37 grains                             140 grain Sierra BT                          2132                                        fair
36 grains                            175 grain Hornady                            1966                                      very consistent   

 The 7 mm Remington magnum has been around for over 50 years and is justly popular so it would make sense to try some 209 in it.  The velocity obtained with the 139 would be similar to a 7 X 57 or 7 mm 08 with standard loads.
LOAD                                          BULLET                                          VELOCITY                                   COMMENT
59 grains                                   139 grain flat base                       2665                                          consistent
 The 30-40 Krag has been around for over 120 years and there are still a fairly decent number of rifles still in use. I used a cast bullet in this test but a jacketed one can be substituted.
LOAD                                       BULLET                                          VELOCITY                                    COMMENT
38 grains                                165 grain cast                               1568                                            nice

 Since the 308 is universally used it will be included in this test. I used a Springfield Armory SAR 4800 to see how it would feed and cycle this ammo. I shot 150’s and 165’s and except for the first two shots cycling was perfect.
LOAD                                       BULLET                                             VELOCITY                              COMMENT
36.5  grains                            150 grain FMJ                                  1907                                     consistent
36                                             165 grain Hornady Interlock        1930                                     high es



30-06 case full   209 takes up a lot of space

 30-06 Loads all using Blackhorn 209. I used military cases because since they are older and don’t possess the quality of newer cases if a problem crops up it may show more readily with these pieces of brass. Bullets used will be the plain cup & core because hi-tec bullets will not give any advantage because of the lower velocities encountered.  Also long tapered boat-tail bullets will take up more space so cutting down on the powder charge, reducing the velocity. With that thought the more blunt and short the bullet the better.   After tapping down powder level was ½ the way up the neck for both the 165 and 180 grain slugs. While I am not going to use a lot of cast bullets a couple might be instructive in a couple of ways. Velocities are similar to full power 30-30 loads so would be useful for the same type of hunting. There is a school of thought that a lot of power is needed for deer size animals. I would say that if you have a bullet of some weight and velocity and possess some hunting skill your hunting will be successful. A little research reveals that a lot of large game has been harvested with lower power rifles and cast bullets and that formula still works. Naturally the long range shots will be ruled out but most big game is shot within 200 yards many much less. At woods ranges, I would feel comfortable hunting with many of these loads.  Since these loads are relatively sedate round nose bullets may be more desirable. They would be more likely to open up at low velocities and this would apply to all of the calibers. The 30-30 style flat nose would be ideal as a bullet with a high ballistic coefficient would have no advantage at these velocities and ranges.
LOAD                                   BULLET                                             VELOCITY                              COMMENT   
48 grains                    150 grain Privi FMJ   (Garand)             2198                                      fed ok
48 grains                    150 grain Privi      (bolt rifle)                2314                                     consistent
44 grains                    165 grain Hornady  flat base                2204                                      decent
44 grains                   165 grain Hornady flat base                 2198  ( Garand )               fed fine
44 grains                    165 grain cast FP                                   2182                                       high es
44 grains                    180 grain Remington Core Loc            2137                                      nice load
44 grains                    200 grain Speer flat base                    2052                                       nice



Blackhorn burns dirty and is mildey corrosive


 The 30-30 has been around for about 120 years and is very common and it works ok with 209. The velocity isn’t very fast by today’s standards but in a pinch will do ok at close range. You are giving up 5-600 FPS with the 209 but it beats throwing the bullet.
LOAD                                      BULLET                                         VELOCITY                              COMMENT
25 grains                            165 grain cast                                  1606                                    consistent
25 grains                            165 grain spitzer                             1565                                   ok       
 The 300 Winchester mag has been around for over 50 years and is one of the most popular magnum rounds and is well distributed. With that thought in mind some load data with 209 would be useful in an emergency.  Heavier bullets should be impressive in this caliber.  This load is in the area of a full power 308 which would make it quite a good hunting load.
LOAD                                   BULLET                                           VELOCITY                                COMMENT
62 grains                            180 grain                                        2469                                        nice
 The 303 is another common military rifle with many still in use. Like the Krag I used a cast bullet with good results.
LOAD                                 BULLET                                             VELOCITY                                COMMENT
33 grains                         165 grain cast GC                            1869                                   very consistent
Another oldie is the 32-40 Winchester. It is on the small side for deer but with a 170 grain flat nose enough velocity is produced to make a fairly decent close range hunting load.
23 grains                        170 grain Hornady                           1541                                     accurate
 I have a good feel for this powder and the larger the case the more power you can get. I have worked with a lot of obsolete rounds such as the 11 X 60 Gras and the 43 Spanish. The ballistics are impressive for  these old rounds. It works ok in a 45-70 but in a 45-120 it is a beast. With a 500 grain bullet I obtained over 1700 FPS and more then a little recoil. I never had any loads that produced excess pressure but I imagine if you took a 378 Weatherby case and necked it down to a 22 pressures might be too high. I have no intentions of trying that out.  I have used it in small cases such as a 9.4 Dutch and while it works ballistics are rather pedestrian.

270 win with 209

5 comments:

Unknown said...

This one seems to me really interesting. Nicely explained. Those who are interested in guns can find it really helpful in knowing everything regarding guns in detail. For this you can also find the people can take help from the MA Gun License and the firearms training center really interesting as they can let you know about all these things in detail.

william said...

thanks for sharing this wonderful idea. i learn a lot and you inspire us. keep posting
Western Boots

jones said...

Ruger AR 556

The Ruger AR 556 is an inexpensivebrowning bss, durable, and dependable semi-computerized rifle that may be utilized in domestic protection and carrying applications competitions, plinking,. The Ruger AR 556 is constructed from aerospace-grade aluminum with a purpose to resist any torture take a look at you may run it via.browning bt 99 reviews The barrel may be very properly made with a medium contour barrel this is cold-hammer solid from chrome-molly metallic for clean upkeep and appreciably advanced longevity. The hand guards are heat-proof against make certain that you may spend all day at the variety and now no longer soften your hand guards or ought to put on gloves whilst you shoot.aac illusion 9 However, beretta 692 sportingin case you desired to put on gloves,ddm4 v7 pro the enlarged cause defend will accommodate thicker gloves without lowering the weapon’s capabilities.


EMAIL >>>>>support@buybestguns.com

WHATSAPP >>>>>1(323)435-7489

jones said...

Welcome to our online store todaybrowning bss. GUN HUSTLE has been around for about 10 years now aac illusion 9, operating a local firearm store in Oregonddm4 v7 pro, United States.arsenal 107ur We have over 1000 satisfied customer worldwide but don’t take our word for itsig p229 equinoxp229 equinox, we invite you to come join our alittle community and experience we conduct our business with quality efficiency and reliabilityzpap m70. We sell Firearmsbrowning single shot trap shotgunhttps://gunhustle.com/product/short-gun-online/, Silencers and even Bulk Ammunitions though we currently haven’t display all these in our online store.


if interested contact us via the following .



call/text....+1(505)257-5355
email....bcvsgea1124@gmail.com

Anonymous said...

This called MISUSING RELOADING COMPONENTS, a dangerous practice that people who SHOULD know better still perform. And this is especially dangerous because this component is a propellant. About it, Hodgdon says "Blackhorn 209 is a low residue, high performance propellant made for muzzleloaders and black powder cartridges.". Got that? "Made for muzzleloaders and black powder cartridges". After reading Bob's first sentence... "In the past, I have used this propellant in applications that it wasn’t designed for"... you learn all you need to know about "Bob". STAY AWAY FROM HIM. DON'T FOLLOW HIS ADVICE. DON'T READ HIS DANGEROUS B.S.